Suzhou Electric Appliance Research Institute
期刊號: CN32-1800/TM| ISSN1007-3175

Article retrieval

文章檢索

首頁 >> 文章檢索 >> 往年索引

一起500 kV線路復合絕緣子發熱缺陷分析

來源:電工電氣發布時間:2023-10-28 09:28 瀏覽次數:171

一起500 kV線路復合絕緣子發熱缺陷分析

吳旭翔1,朱其杰2,李特2,楊先進1,葉金標3,陶瑞祥2
(1 國網浙江省電力有限公司杭州供電公司,浙江 杭州 310004;
2 國網浙江省電力有限公司電力科學研究院,浙江 杭州 310014;
3 浙江金鳳凰電力科技有限公司,浙江 紹興 312399)
 
    摘 要:復合絕緣子發熱缺陷會對輸電線路的安全穩定運行構成嚴重威脅。針對一起 500 kV 線路復合絕緣子發熱事件,對該線路兩種型號的發熱絕緣子進行了外觀檢查、紅外檢測、解剖檢查、憎水性試驗、滲透性試驗、水擴散試驗、密封性試驗,分析了復合絕緣子發熱的缺陷及發熱原因。結果表明:兩種型號發熱絕緣子均存在芯棒-護套粘接不良缺陷,同時水擴散泄漏電流幅值超過標準值,該缺陷是導致絕緣子芯棒酥朽并發熱的原因。針對該缺陷提出了運行維護建議。
    關鍵詞: 復合絕緣子;發熱;芯棒酥朽;粘接
    中圖分類號:TM216     文獻標識碼:B     文章編號:1007-3175(2023)10-0036-06
 
Analysis of the Composite Insulator Heating of 500 kV Line
 
WU Xu-xiang1, ZHU Qi-jie2, LI Te2, YANG Xian-jin1, YE Jin-biao3, TAO Rui-xiang2
(1 State Grid Zhejiang Electric Power Co., Ltd. Hangzhou Power Supply Company, Hangzhou 310004, China;
2 State Grid Zhejiang Electric Power Co., Ltd. Electric Power Research Institute, Hangzhou 310014, China;
3 Zhejiang Golden Phoenix Electrical Co., Ltd, Shaoxing 312399, China)
 
    Abstract: The heating of composite insulators poses a serious threat to the safe and stable operation of transmission lines. In this paper, a composite insulator heating accident of the 500 kV line is introduced. The appearance inspection, infrared detection, anatomical examination,hydrophobicity test, permeability test, water-diffusion test and sealing test of two types of heating insulators of the line haven been carried out, and their heating defects and causes were also analyzed. According to the results, two types of heating insulators both have bad mandrel-sheath bonding, and the amplitude of water diffusion leakage current exceeds the standard value, which are causes of mandrel crisp and heating. Therefore, suggestions of how to correct this defect have been given.
    Key words: composite insulator; heating; mandrel crisp; bonding
 
參考文獻
[1] 關志成,劉瑛巖,周遠翔,等. 絕緣子及輸變電設備外絕緣[M]. 北京:清華大學出版社,2006.
[2] 王曉杰, 許軍, 林朝暉, 等. 輸電線路復合絕緣子溫升現象及其成因分析[J] . 電瓷避雷器,2022(5) :165-171.
[3] 屠幼萍,陳聰慧,佟宇梁,等. 現場運行復合絕緣子傘裙材料的老化判斷方法[J] . 高電壓技術,2012,38(10) :2522-2527.
[4] 高巖峰,梁曦東. 復合絕緣子酥朽斷裂研究(二):酥朽斷裂的試驗?zāi)M及預防措施討論[J] . 中國電機工程學報,2016,36(18) :5070-5077.
[5] 曾志偉,曾向君,張福增,等.500 kV 核惠線合成絕緣子異常發熱原因分析[J] . 南方電網技術,2018,12(5) :51-55.
[6] VAILLANCOURT G H, HAMEL M, FRATE J.Experience with Two Fault Composite Insulators Detection Methods in Hydro-Quebec[C]//10th International Symposium on High Voltage Engineering,1997 :1467-1471.
[7] SPANGENTERG E, RIQUEL G.In Service Diagnostic of Composite Insulators EDF’s Test Results[C]//10th International Symposium on High Voltage Engineering,1997 :139-142.
[8] 程養春, 李成榕, 陳勉, 等. 高壓輸電線路復合絕緣子發熱機理的研究[J] . 電網技術,2005,29(5) :57-60.
[9] 成立,梅紅偉,王黎明,等. 復合絕緣子用硅橡膠護套長時間老化特性及其影響因素[J] . 電網技術,2016,40(6) :1901-1907.
[10] 黃成才,李永剛. 復合絕緣子老化狀態評估方法研究綜述[J]. 電力建設,2014,35(9) :28-34.
[11] 王少華,葉自強,羅盛.500 kV 復合絕緣子斷裂機理及檢測方法[J]. 中國電力,2011,44(8) :19-21.
[12] 段玉兵,胡曉黎,雍軍,等.500 kV 復合絕緣子現場紅外測溫方法及診斷判據[J] . 山東電力技術,2014, 41(4) :29-31.
[13] 盧明,張中浩,李黎,等. 復合絕緣子酥朽發熱老化的原因分析[J] . 電網技術,2018,42(4) :1335-1341.
[14] 陳奇. 高壓復合絕緣子應用及老化狀態研究綜述[J].絕緣材料,2016,49(4) :7-13.
[15] 盧明,胡文,李黎,等. 交流500 kV 復合絕緣子芯棒斷裂原因分析[J] . 電瓷避雷器,2015(3) :23-28.
[16] 王黎明,聶章翔,趙晨龍,等. 水分在環氧樹脂復合絕緣子護套中的滲透特性[J] . 高電壓技術,2019,45(1) :173-180.
[17] 樊浩楠,劉育豪,王黎明,等. 環氧樹脂絕緣子合??p對水擴散試驗的影響[J] . 電網技術,2021,45(6) :2420-2426.